| 1 | 0 | 3 | 4 | 3 | 4 |
2014 Ford Fusion repairs by problem area
Engine (18%)
Transmission and Drivetrain (5%)
Brakes and Traction Control (0%)
Suspension and Steering (9%)
Electrical and Air Conditioning (31%)
Paint, Rust, Leaks, Rattles, and Trim (21%)
Other (16%)
Chart based on 121 repairs.
2014 Ford Fusion repair cost distribution
$2500+ (0%)
$1000 - $2499 (1%)
$500 - $999 (4%)
$100 - $499 (25%)
< $100 (70%)
Chart based on 76 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2014 Ford Fusion 4dr Sedan
turbocharged 240hp 2.0L I4 6-speed shiftable automatic FWD
| Ford Fusion in New York, United States Sep 2015 - Feb 2022 | |||
| Oct 201640300 miUS $100 | AC compressor clutch "blew up". Replaced with entire new compressor, included a recharge. | ||
| Feb 202270000 miUS $600 | ball joint assembly | ||
| Ford Fusion in Virginia, United States Oct 2015 - Oct 2016 | |||
| Mar 201632000 mi | Car would not start, battery dead, nothing was left on, and battery successfully recharged. | ||
| Ford Fusion in Florida, United States Jun 2014 - Sep 2017 | |||
| Dec 201513000 mi | Replaced Worn Steering Wheel | ||
| Mar 201622000 mi | Inside of sunroof was rusted, no evident leaks. | ||
| Ford Fusion in Kansas, United States May 2015 - Jun 2016 | |||
| May 201512000 mi | Bad fuel pressure sensor. | ||
| Ford Fusion in California, United States May 2014 - Sep 2014 | |||
| Jul 20142500 mi | Sync voice activated mic not working. | ||
| Ford Fusion in Washington, United States Nov 2015 - Nov 2016 | |||
| Jul 201636500 mi | Front and rear leather seats started to show wear. Both front leather seatbacks were replaced along with rear leather bench. | ||
| Ford Fusion in Pennsylvania, United States Aug 2016 - Jul 2018 | |||
| Jun 201751000 mi | Recall repair performed on front seat belt pretensioners | ||
| Ford Fusion in Ohio, United States Aug 2014 - Jan 2022 | |||
| Mar 201827000 mi | Safety recall on Seatbelt Latch | ||
| Jan 202274000 miUS $2150 | Driver side would only blow cold air. The climate control unit had a broken door so couldn't flip to hot air. Needed to pull out dash to replace $1100 part. | ||
| Ford Fusion in Texas, United States Feb 2014 - Jun 2018 | |||
| Jan 201837000 miUS $85 | Dead Battery | ||
| Ford Fusion in California, United States Jan 2014 - Oct 2018 | |||
| Aug 201743500 miUS $109 | Replaced swollen log nuts on all four wheels. | ||
| Ford Fusion in California, United States Sep 2015 - Sep 2016 | |||
| Dec 201519000 miUS $40 | Driver-side headlight would flicker when turn signal was engaged. Dealer mechanics corrected the issue with a BCM update. Nearly a year later, the issue has never returned. | ||
| Ford Fusion in California, United States Jan 2014 - Jun 2022 | |||
| Dec 201629000 mi | Firewall sound deadening in the engine compartment was falling apart. Replaced under warranty. | ||
| Dec 201736000 mi | Recall performed for seatbelt pre-tensioner corrosion issue. Lubricant applied to affected cable. | ||
| Ford Fusion in Oklahoma, United States Apr 2014 - Dec 2015 | |||
| Nov 201410000 mi | Backseat (probably inflatable rear seatbelt buckles) rattles at highway speed no matter the road surface. Couldn't replicate rattle in backseat. Window trim piece on driver's front unclipped (maybe broken). "Fixed" wrong trim piece. | ||
| Mar 201515000 mi | Harsh shifting Trans, missing Rev matches, and occasional hesitation. Also radio volume increasing with no driver input. Supposedly dealer performed PCM software update and reflash of My Ford touch software. Volume:fixed, Trans: not fixed | ||
| Ford Fusion in New Jersey, United States Oct 2013 - Jul 2022 | |||
| Apr 201513200 mi | Spring in the rear seat grab handle above the window broke and needed to be replaced. | ||
| Ford Fusion in New York, United States Sep 2013 - Oct 2016 | |||
| Dec 20134000 mi | Radio stopped receiving HD broadcasts. | ||
| Feb 20146000 mi | Various parts needed to be replaced inside transmission due to slippage in first three gears. Problem was aggravated by the cold weather. | ||
| Mar 20147000 mi | HD radio stopped receiving HD broadcasts. | ||
| May 201410000 mi | Popping sound coming from underneath driver's side of the car. The dealer tried refastening a panel underneath the car. | ||
| Jul 201412700 mi | Popping noise from underneath left side of the car. Unable to pinpoint and fix. They tried a few more things. Will attempt again in October. | ||
| Feb 201629000 mi | Rear left hub bearing replaced. | ||
2014 Ford Fusion 4dr Sedan
turbocharged 240hp 2.0L I4 6-speed shiftable automatic AWD
| Ford Fusion in Michigan, United States Jul 2014 - Jun 2018 | |||
| Dec 201519000 mi | Gas tank filler system needed to be replaced | ||
| Ford Fusion in Michigan, United States Feb 2014 - Oct 2018 | |||
| May 201518300 miUS $250 | Noticed right rear ball bearing noise, took to shop. Found bent right rear rim, replaced bearings and re-aligned. Covered under insurance. Days later noticed front bearings needed to be replaced. Covered under warranty. | ||
| Ford Fusion in Massachusetts, United States Dec 2014 - Mar 2019 | |||
| Dec 20145000 mi | Heated Steering wheel failed to get warm when activated. Heating controller replaced. Left headlight flickers when blinkers activated. Replaced BCM and reprogram to fix problem | ||
| Jun 20159000 mi | Collision System disabled (sensor blocked). System worked fine after car restart. Service tech found code c1a67 and performed horizontal aim procedure. Banging noise coming from rear deck / trunk over certain bumps. Trunk torsion bars were banging against metal. Dealer added padding to prevent noise. Driver seatbelt would lock under medium acceleration & turns and not release easily. Tech replaced Pretensioner & Seat Belt - Part DG9Z 54611B09 | ||
| Nov 201516000 mi | Drivers seatbelt is sticking and not unlocking. Same part replaced as last time, I expect the problem will return again | ||
| Jan 20167700 mi | Replaced rear passenger shock and mounting bracket because of metallic noise over potholes. Problem still present. | ||
| Feb 201619700 mi | rattle when going over pothole. Amp loose in mounting bracket in trunk. | ||
| May 201735500 mi | Drive axel boot seal leaking. Replaced seal with new one | ||
2014 Ford Fusion 4dr Sedan
turbocharged 178hp 1.6L I4 6-speed manual FWD
| Ford Fusion in California, United States Jan 2014 - Jul 2022 | |||
| Aug 201623900 mi | Air conditioner was not blowing cold. Dealer replaced parts. | ||
| Feb 201728000 mi | Wire clip was loose in headliner, producing rattling noise. Fix covered under warranty. | ||
| Ford Fusion in Texas, United States Aug 2014 - Jun 2018 | |||
| Dec 201641000 miUS $177 | Purge valve needed replacement due to delayed closing | ||
| Nov 201756000 miUS $50 | Air intake was no longer affixed to turbo causing increased turbo whine and decreased performance requiring replacement of bolts-not covered under warranty Water pump found to be leaking during service and replaced under warranty recall repairs to coolant sensor performed | ||
| Jun 201861000 miUS $250 | Interior hood latch broken requiring replacement to allow for opening of hood | ||
2014 Ford Fusion 4dr Sedan
turbocharged 178hp 1.5L I4 6-speed shiftable automatic FWD
| Ford Fusion in California, United States Sep 2015 - Oct 2018 | |||
| Mar 201644000 miUS $100 | Power door lock remote not working | ||
| Jun 201760000 miUS $100 | Replaced the purge valve assembly after check engine light revealed code P 01450. The Ford dealer fixed it while also doing the 60 thou mile service. Cost me the 100 dollar ESP care deductible. It was causing the car to have trouble starting after refueling. | ||
| Dec 201770000 miUS $100 | Powertrain fault resulting in sudden deceleration. Required replacing existing part. UnderESP warranty to 100 thou miles | ||
| Ford Fusion in California, United States Aug 2016 - Dec 2016 | |||
| Nov 201631000 mi | Bad fuel sensor caused car to die when idling | ||
| Ford Fusion in Illinois, United States Aug 2014 - Sep 2018 | |||
| Sep 201526000 mi | Water pump was replaced | ||
| Ford Fusion in Quebec, Canada Dec 2015 - Jul 2018 | |||
| Jun 201714260 mi | Recall for faulty part in seat belt tensionner | ||
| Ford Fusion in Wisconsin, United States Aug 2014 - Jun 2016 | |||
| Feb 201617000 mi | Power steering (and traction control) went out one day. Dealer replaced a steering gear. | ||
| Ford Fusion in Louisiana, United States Jun 2014 - Jun 2022 | |||
| Aug 20141200 mi | The right interior grab handle was defective from the factory and was replaced under warranty. | ||
| Ford Fusion in Michigan, United States May 2014 - Jan 2015 | |||
| Jun 20141000 mi | Had a piece of interior trim replaced for an injection molding visual defect (splay). | ||
| Aug 20145000 mi | The car wouldn't start because it wouldn't recognize any of my keys. The remote start function also failed. Body computer and wireless control module were both bad. | ||
| Sep 20146000 mi | After the body computer and wireless control module were replaced, the car still didn't start after 1 day. Wires were pinched between the instrument panel and firewall, creating a short on the wake up signal wire. | ||
| Ford Fusion in Maine, United States Apr 2014 - Sep 2018 | |||
| Dec 201534000 mi | Engine vibrating at idle, both in gear or in neutral. Chaffed wires in dash were suggested as the culprit. Fixing them didn't fix the vibration. Also, radio would not turn on during one trip. They thought the chaffed wires were responsible, and it hasn't happened again. | ||
| May 201760000 miUS $120 | Replaced rear shocks due to rear end noise. | ||
| Ford Fusion in New Jersey, United States Aug 2014 - Sep 2016 | |||
| Feb 20159000 mi | Bezel to drivers side exterior door handle fell of car. Needed replacement piece. | ||
2014 Ford Fusion 4dr Sedan
175-horsepower 2.5L I4 6-speed shiftable automatic FWD
| Ford Fusion in Maryland, United States Feb 2015 - Jun 2018 | |||
| Jun 20154000 mi | Headliner replace as per ssm 44717 | ||
| Ford Fusion in Michigan, United States Mar 2017 - Feb 2022 | |||
| Jul 201736200 miUS $42 | Driver's power mirror would not adjust left-to-right. Dealer charged $100 to diagnose the problem and wanted an additional $280 for the repair. I declined the estimate. I purchased a genuine Ford power mirror motor for $40 plus tax -- about 30% less than what the dealer wanted for the same part -- and spent half an hour installing it. | ||
| Apr 201843000 mi | The torsion spring that holds the left rear grab handle up against the headliner popped out of its seat, allowing the handle to hang down. I used a screwdriver and a needle-nose pliers to push the spring tail back into its seat. The job took less than half an hour and cost me nothing. | ||
| May 202062400 miUS $200 | Battery was replaced to address a slow cranking issue. | ||
| Ford Fusion in British Columbia, Canada Apr 2014 - Jan 2017 | |||
| Jan 2015 | Trunk hinges squeeked when opening and closing | ||
| May 201531000 mi | Drivetrain repair | ||
| Feb 201647640 miC $200 | Rear air vents broken. | ||
| Apr 201652700 miC $200 | Fuel Door Housing Replaced | ||
| Jun 201655180 miC $600 | Overhaed Counsole replace because glasses holder door broke...stayed open, would not close. | ||
| Jan 201768200 miC $135 | Replaced battery. | ||
| Ford Fusion in Minnesota, United States Jan 2014 - Nov 2015 | |||
| Feb 201511000 miUS $25 | Tire seal at rim was leaking air. Applied sealant. | ||
| Ford Fusion in Ohio, United States May 2014 - Apr 2017 | |||
| Sep 20143000 mi | seat belt stuck------ replacement | ||
| Ford Fusion in California, United States Aug 2014 - Jun 2016 | |||
| Aug 20155100 mi | Plastic trim around sun visor fell off; plastic peg that kept it in place fell off. | ||
| Ford Fusion in New York, United States Jul 2013 - Nov 2016 | |||
| Aug 201658000 mi | Flat tie. Lug nuts were swelled. Wrench included with car did not fit lug nuts. Lug nets that swell so you can't change the tire yourself strikes me as a design defect. | ||
| Nov 201661000 mi | Lug nuts were swollen, such that the wrench included with the car could not longer be used to remove them to change a tire. | ||
| Ford Fusion in Virginia, United States Aug 2015 - Sep 2015 | |||
| Sep 201512000 mi | Engine lags @ times after stopping for traffic light.MECHANIC DROVE VEHICLE APPROX 20 MILES WITH ME AS RIDER IT DID NOT OCCUR. | ||
| Ford Fusion in Michigan, United States Jun 2014 - Jul 2017 | |||
| Mar 201615000 mi | Engine icon came on. 1st reported as gas tank pressure leak. replaced a seal on gas tank. Engine icon came back. 2nd reported as wiring problem. | ||
| Ford Fusion in Texas, United States Mar 2015 - Oct 2019 | |||
| May 201619600 mi | Change oil prompt will not reset, dealer is unable to repair. | ||
| May 201732000 mi | seat tensioner failure? failure of door lock and latch right rear door covered under recall | ||
2014 Ford Fusion 4dr Sedan
141-horsepower 2.0L I4 Plug-in Hybrid CVT FWD
| Ford Fusion in Georgia, United States Nov 2016 - Jul 2018 | |||
| Dec 201620000 mi | Charging light port ring replaced under warranty | ||
| Ford Fusion in California, United States Nov 2013 - Jun 2018 | |||
| Apr 20143500 mi | Reflash computer per TSB to remove check engine light. Replaced grab handle above front passenger door. Spring had snapped out and could not be reseated. | ||
| Dec 201412000 mi | Driver's headlight flickers when headlights and turn signals on. Replaced BCM. Trim between windows on drivers door kept popping out, causing wind noise. Replaced driver and passenger trim. | ||
| Ford Fusion in Alabama, United States Apr 2014 - Jun 2016 | |||
| Dec 201411000 mi | Emissions sensor replaced | ||
| Ford Fusion in Virginia, United States Jun 2014 - Feb 2019 | |||
| Dec 20145000 mi | Seat motor started sounding different. Worked perfectly fine but I didn't want it to later go out after the warranty was over. I had the auto-easy-entry/exit option on. Ford replaced it the same day for free without hassle. | ||
| Ford Fusion in North Carolina, United States Apr 2014 - Feb 2022 | |||
| Aug 20143000 mi | Sunroof wind noise. Dealer adjusted the sunroof. Repair was covered under warranty. | ||
| Oct 20145300 mi | Musty smell when first turning on AC. Black piano trim around window switches on both rear doors were bowing up. Ambient lighting color would revert to ice blue after car was power cycled. Dealer installed new software to fix problem. High Definition (HD) stopped working in the radio function. Dealer installed new software to fix the problem. | ||
| Mar 201834000 mi | Center console kept rebooting itself continuously. Dealer replaced the APIM under warranty. | ||
| Sep 202165500 miUS $45 | Lug nuts were “swollen” and were replaced. | ||
| Ford Fusion in New York, United States Mar 2014 - Mar 2017 | |||
| Aug 201635000 mi | seal in the gas door was was allowingfumes to escape. | ||
| Ford Fusion in California, United States Aug 2014 - Sep 2016 | |||
| Jan 201632200 mi | Charge port for Hybrid battery was replaced | ||
2014 Ford Fusion 4dr Sedan
141-horsepower 2.0L I4 Hybrid CVT FWD
| Ford Fusion in California, United States Jun 2014 - Jan 2018 | |||
| Jan 201868000 miUS $34 | Nav, hvac, audio display keeps shutting off and shoeing error message. Dealer not able to diagnose or replicate intermittent issue | ||
| Ford Fusion in Texas, United States May 2014 - Jul 2017 | |||
| Jun 201620000 mi | Passenger side blind spot module defect. | ||
| Ford Fusion in Florida, United States Aug 2013 - Jun 2022 | |||
| Mar 201510000 mi | Defective cam shaft sensor Part was not in stock. | ||
| Ford Fusion in California, United States Nov 2013 - Jun 2018 | |||
| Jun 201531000 mi | Daylight sensor for automatic headlights was not functioning. | ||
| Ford Fusion in Minnesota, United States Apr 2015 - Jun 2018 | |||
| Mar 201635000 mi | R&R timing chain cover due to oil leak. 120V AC outlet in back was broken and not providing power to plugged in device. | ||
| Ford Fusion in Illinois, United States Dec 2013 - Sep 2021 | |||
| Sep 201638000 miUS $140 | leaking shock absorber | ||
| Aug 201751000 mi | Door interior handle and seat belt recalls done Previously replace shock absorber started leaking fluid | ||
| Ford Fusion in Manitoba, Canada Nov 2016 - Dec 2016 | |||
| Nov 201659520 miC $350 | 120 V outlet in the rear cabin wasn't working when I plug in a laptop despite wattage within 150W limit (laptop was only 90W) also the power lumbar stopped functioning on the driver's seat | ||
| Ford Fusion in Virginia, United States Aug 2014 - Jun 2018 | |||
| Dec 20146000 mi | When the car runs on the gas motor it vibrates thru the steering wheel, gas pedal, brake pedal.And makes a lot of noise from the engine. When it goes back to electric, it has no vibration & no noise. Dealer said this is normal for the hybrid | ||
| Jun 201515000 mi | When the car runs in gas mode only the engine is very noisy and has a lot of vibration coming thru steering wheel, center console etc. The tech had me drive a new Fusion Hybrid & it did the same thing. Plan on getting rid of car ASAP. | ||
| Oct 201521800 miUS $45 | Gas engine vibrates & makes excessive noise. Runs fine when in electric mode. | ||
| Jan 201863000 mi | Recall on seatbelt tensioner | ||
| Ford Fusion in New York, United States Dec 2013 - Jan 2022 | |||
| Oct 201549000 mi | Cruise Control button on steering wheel stopped working. The button was replaced under warranty. | ||
| Apr 2017113000 miUS $397 | The left front headlight burned out, necessitating a removal of the entire front end of the car (a design "feature" of all 2013 and beyond Fusions). I had both headlights replaced (might as well) and also changed the oil (it was due). | ||
| Sep 2017128000 miUS $762 | I originally went in to change my four tires, but Mavis Tire talked me into replacing my front struts. Turns out the car started making a terrible scraping noise. | ||
| Oct 2017129000 mi | Mavis Tire replaced one of their new struts from September that was making a scraping noise with a new Ford OEM strut. And the noise persisted. Freedom Ford confirmed that the correct strut had been installed by Mavis Tire, but that it was installed incorrectly. The top edge of the strut was scraping against the inside of the car's body. Ford re-installed the strut correctly and now, the car makes no noise. | ||
| Ford Fusion in Virginia, United States Nov 2013 - Jun 2022 | |||
| Jul 201513300 mi | Check engine light was on. Diagnosis was done but no fault was found. The check engine light was reset. | ||
| Sep 201625000 mi | The 110V 3-pin socket was too loose, did not hold the plug in. The socket had to be replaced. | ||
| Sep 201740000 mi | The 110v AC outlet had problems with inverter. Dealer claimed this was due to plugging in an appliances rated more than the maximum the outlet can handle (150W). I do not recall using an appliance rated at more than 150W. Dealer fixed the issue under warranty. | ||
| Ford Fusion in California, United States Jan 2018 - Jun 2018 | |||
| Jun 2018130000 miUS $229 | Transmission leak. Removed bottom transmission case bolts, reseal with adhesive and install case bolts and refill transmission. | ||
2014 Ford Fusion 4-door
6-cylinder hybrid automatic 2WD
| Ford Fusion in Texas, United States Sep 2013 - Jun 2022 | |||
| Jul 201416000 mi | Rear passenger belt would not buckle and a new one had to be ordered and destroyed. | ||
| Jan 201736700 miUS $202 | Back up camera went out | ||
See TrueDelta's information for all Sedans
See TrueDelta's information for all Ford models.
