| 1 | 0 | 3 | 4 | 3 | 4 |
2008 Ford Fusion repairs by problem area
Engine (29%)
Transmission and Drivetrain (8%)
Brakes and Traction Control (12%)
Suspension and Steering (6%)
Electrical and Air Conditioning (24%)
Paint, Rust, Leaks, Rattles, and Trim (12%)
Other (9%)
Chart based on 182 repairs.
2008 Ford Fusion repair cost distribution
$2500+ (1%)
$1000 - $2499 (6%)
$500 - $999 (17%)
$100 - $499 (40%)
< $100 (37%)
Chart based on 136 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2008 Ford Fusion
Engine not specified
| Ford Fusion in Alabama, United States Aug 2015 - Sep 2015 | |||
| Aug 201599000 miUS $100 | Ac would ruin my gas mileage by >8 mpg Rpm dropped below 500 when running it and would almost stall my car out. | ||
| Sep 2015102000 mi | Fuel pump busted or fell off. Air conditioner was leaking out into my floor. Brakes gradually stopped working, Fluid was leaking, And needed to be replaced | ||
2008 Ford Fusion 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic FWD
| Ford Fusion in Missouri, United States Mar 2011 - Oct 2015 | |||
| Jul 201281500 miUS $2000 | Engine control computer replaced | ||
| Ford Fusion in Michigan, United States - Nov 2008 | |||
| Nov 200813000 mi | Brake caliper :snapping on the disk when brake is applied . | ||
| Ford Fusion in California, United States Mar 2008 - Jun 2022 | |||
| Feb 201121300 mi | RR door latch mechanism sticking... auto unlock worked only intermittently. Latch mechanism was replaced by dealer under original Ford warranty. Auto-dimming mirror sometimes does not dim from auto headlights to rear of car... dealer claimed it is working to spec. Do not know how it was tested; test might have been invalid, i.e. light applied up close. | ||
| Ford Fusion in Ohio, United States Nov 2010 - May 2011 | |||
| May 201029000 mi | Battery cable and battery replaced under warranty due to serious corrosion at the positive battery terminal connector | ||
| Ford Fusion in Washington, United States Jan 2010 - Jun 2018 | |||
| Jul 2016162700 miUS $70 | Leaking A/C required recharging. | ||
| May 2017176000 miUS $750 | Evaporator core was leaking, and replaced evap temp sensor as a preventive maintenance item. | ||
| Dec 2017184000 miUS $725 | Hydraulic Control Unit was replaced to correct low brake pedal due to stuck valves in HCU. This is a common Fusion problem. HCU cost was $600, labor was $125. | ||
| May 2018190000 miUS $100 | Replaced master cylinder to resolve soft brake feel and too much pedal travel. | ||
| Ford Fusion in Tennessee, United States Feb 2009 - Jun 2017 | |||
| Mar 200917000 mi | Very loud noise coming from the engine area. According to the dealer, they replaced a cracked air conditioning refrigerant line and the compressor, as well as the accumulator. | ||
| Ford Fusion in Arizona, United States Aug 2016 - Jul 2018 | |||
| Jul 2017125000 miUS $700 | Left front wheel was making an awful clunking/howling noise and felt loose when wiggled while on a jack. Wheel bearing was replaced. Left halfshaft was replaced as well due to torn boots. | ||
| Ford Fusion in New York, United States Aug 2008 - Nov 2013 | |||
| Oct 20083000 mi | Paint on exterior entry keypad was blemished. Passenger's air bag door on dash is warped and rippled. Dealer realigned and said that warp will disappear when door is heated by the sun. | ||
| Feb 201022000 mi | Analog clock began running between 5 and 15 minutes fast every 24 hours. Also, hour hand was falling behind and it became impossible to tell the correct time. HVAC auto climate control head unit does not start up if left overnight during cold weather. Unit resets to "Off" and also loses stored temperature setting. Unit has to be manually switched back to "on" afetr starting the car. | ||
| Dec 201033000 mi | There was noise and vibration coming from the steering column at times. Dealer tightened hose connection on power steering pump and added more fluid. | ||
| Dec 201255000 miUS $150 | Interior door latch for driver's door broke. Door could not be opened from the inside. | ||
| Aug 201359600 miUS $2100 | Moon roof track was broken and motor contained plastic shards from the track. | ||
| Ford Fusion in Idaho, United States Jul 2009 - Jun 2016 | |||
| Jan 201345000 miUS $50 | Replaced headlamps. | ||
| Ford Fusion in Ontario, Canada Jan 2016 - Feb 2016 | |||
| Jan 2016119660 miC $1675 | Broken engine mount | ||
| Ford Fusion in Arkansas, United States Mar 2008 - Nov 2010 | |||
| Oct 20083000 mi | I had them replace one of the small clips that holds the front bumper cover so it would not stick out (I was being picky). | ||
| Ford Fusion in Virginia, United States Jan 2021 - Oct 2022 | |||
| Feb 2021110000 miUS $600 | Valve cover gaskets replaced Oil pan gasket replaced Engine and transmission mounts replaced Dash airbag cover re-glued Drivers seat heater replaced | ||
| Sep 2021115550 mi | ABS module replaced Airbag replaced | ||
| Nov 2021117461 miUS $500 | Brakes, rotors replaced Rear brake calipers replaced | ||
| Mar 2022118000 miUS $300 | ECM failed with little warning. Replaced with reconditioned ECM & reprogrammed to car | ||
| Oct 2022121000 miUS $80 | Blower motor squeaking / replaced | ||
| Ford Fusion in Quebec, Canada Jan 2015 - Jun 2022 | |||
| Feb 201575940 miC $800 | I lost almost all transmission fluid. The indication was a burnt smell in the car. Was able to take the car to the dealer. They change tubes running from the transmission to radiator and did flushing transmission for 800$. Transmission saved | ||
| Jun 201577500 miC $200 | Oil leak change oil seal | ||
| Feb 201789680 miC $500 | front right caliper and rear left caliper were changed in Canadian Tire store for 500$. The problem was premature end of life of pads because the caliper was frozen. The warranty on pads and disk was used | ||
| Apr 201896957 miC $100 | Ajar switch in the rear (driver side) dysfunction was starting the alarm when the car was very cold so i had to refrain from opening this door during the last winter to get time to research this on the internet. The repair imply to change the whole module for around 400$. It cost me 100$ to find out that the general info on the internet was bad and i ordered the wrong switch. Only the dealer has the good information about this specific module. So for the moment, i am waiting to observe more evident trouble. It manifest only in extreme cold weather. | ||
| Jul 201899200 miC $400 | windshield washer pump was changed with the tubes and 2 water output nozzles for a total of 400$ CND | ||
| Dec 2018102168 miC $427 | change exhaust tube | ||
| May 2022123466 miC $527 | repair of the main exhaust pipe | ||
| Ford Fusion in New Jersey, United States Sep 2007 - Jun 2011 | |||
| Jun 200810000 mi | Starter "catches" sometimes when turning the key. Makes a short "zing" noise. Couldn't replicate it at the dealership nor could I in the parking lot. They were very good and told me to bring it back if it repeated. | ||
| Ford Fusion in Wisconsin, United States Oct 2007 - Dec 2012 | |||
| Apr 20098000 mi | Radio had popping noise. Tire Valve stem replace. Leaky tire | ||
| Sep 201020000 mi | Part described as a module or a sensor. Dash board had to be taken off. Air conditioning would not blow cold air. | ||
| Ford Fusion in Pennsylvania, United States Sep 2013 - Sep 2013 | |||
| Sep 2013102000 mi | 2 Rods thrown, catastrophic failure, no indicator lights, just a loud metallic sound then, BOOM. | ||
| Ford Fusion in Georgia, United States Jan 2008 - Oct 2016 | |||
| Apr 20082000 mi | Driver's side door panel retaining clip(s) had come unseated resulting in loose door panel and clip rolling around inside of door. | ||
| May 201027000 mi | Driver's side seat bolster has collapsed, causing the leather/ette cover material to rip and tear prematurely. Tear spot does not come into human contact. Told Ford would not cover it even though under the 3/36 bumper-2-bumper warranty. | ||
| Jul 201030000 mi | Trunk shocks blew out and would not longer lift or support the trunk. Dealer replaced under warranty. | ||
| Oct 201254500 mi | Valve cover gaskets reported by service tech as leaking. Replaced under 5yr/60K power-train warranty. | ||
| Oct 201676000 mi | Data Link Connector for OBD computer not responding to emissions sync. Diagnosed, checked & corrected. | ||
| Ford Fusion in Alberta, Canada Aug 2012 - Feb 2022 | |||
| Dec 201248360 miC $1290 | Repair oil leak from oil pan and engine output seal | ||
| Jan 201884320 miC $200 | Replaced coolant manifold and temperature sensor due to leak at coolant temperature sensor. | ||
| Ford Fusion in Missouri, United States Jul 2015 - Jun 2022 | |||
| Dec 201689000 miUS $550 | Transmission lines were badly corroded and were leaking. All three lines were replaced. | ||
| May 201895499 miUS $250 | Shocks and struts were replaced. | ||
| Ford Fusion in West Virginia, United States Aug 2013 - Aug 2013 | |||
| Aug 201392000 miUS $400 | door handle on dr. side broke water pump failure | ||
2008 Ford Fusion 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic AWD
| Ford Fusion in Illinois, United States Jan 2012 - Dec 2016 | |||
| Dec 2016135000 miUS $350 | Leaking trans pan gasket. Replace trans pan gasket flush system, and replace filter. | ||
| Ford Fusion in Indiana, United States Aug 2012 - Dec 2013 | |||
| Aug 201376400 miUS $829 | Replaced rear driveshaft due to failed front carrier bearing. | ||
| Ford Fusion in Colorado, United States Feb 2012 - Jan 2018 | |||
| May 201235000 miUS $325 | One of the battery cables attaching to the battery corroded and fell off. I needed to get the Fusion towed to a repair shop. | ||
| Ford Fusion in West Virginia, United States Feb 2012 - Jun 2018 | |||
| Jun 201260000 miUS $30 | Transmission oil cooler lines were rusted and leaking. I replaced them myself. | ||
| Jan 2018167000 miUS $300 | One rear brake was sticking. The caliper and pads were replaced. I had previously replaced the caliper myself, but the one I installed apparently was defective. The driver's side caliper apparently had been sticking somewhat for several years, as that wheel was often hotter than the others and the pads wore out more often. | ||
| Ford Fusion in Massachusetts, United States Mar 2008 - Jun 2018 | |||
| Mar 200920000 mi | Fuel cap needed to be replaced/caused ck engine light to go on. | ||
| Ford Fusion in New York, United States Mar 2008 - Sep 2010 | |||
| Apr 201016700 mi | warped cowl | ||
| Ford Fusion in Pennsylvania, United States Jan 2008 - Sep 2009 | |||
| Feb 20081000 mi | Auto dimming mirror not working correctly, new one ordered and installed. | ||
| Ford Fusion in Alberta, Canada Sep 2007 - Jun 2010 | |||
| Mar 201022940 mi | noise when window going down on drivers side, repaired with tsb for known concern. no charge to customer | ||
| Ford Fusion in Manitoba, Canada Nov 2012 - Jun 2017 | |||
| Jun 201796100 miC $2000 | Transfer case or Power Transfer unit, does not have a drain plug, this is not considered a serviceable part. The only way this can be changed is to remove the part and turn it upside down at 5.5hrs mechanic labour. OEM 1600-2000, wrecker $500 Driveshaft, bad ujoint, again ujoints are not replaceable and you have to buy another driveshaft. OEM 1600, aftermarket 800 Do not buy a ford AWD in the 130km and up range, you are asking for this repair! I know this is my last ford! | ||
| Ford Fusion in Ontario, Canada Mar 2008 - May 2020 | |||
| Aug 20084960 mi | Driver's door sill damaged during installation at factory, noticed as a white dsicoloration of camel colored door sill, part on order from US Rear passenger cushion behind driver unable to support weight of occupant, deformation occurs that does not immediately dissipate when occupant exits seat. Advised by service adviser that although issue noted, unsure if can be fixed. | ||
| Sep 201029140 mi | Moaning noise under power coming from behind driver. Diagnosed by Ford mechanic as a bad hanger bearing, drivershaft replaced, one day wait on parts. | ||
| Jul 201245260 miC $218 | Car began showing symptoms of hard/long cranking (also SRS light would not go out after car started) | ||
| Apr 201885560 miC $1700 | Noise and vibration when driving from right side of car. Dealership diagnosed as two bad right side wheel bearings (front/rear) both replaced and car returned to normal operation | ||
| Ford Fusion in Indiana, United States Mar 2008 - Sep 2014 | |||
| Jun 20083000 mi | Blown passenger front speaker. Audiophile System. | ||
| Jan 200914000 mi | HVAC blower motor squeaking. | ||
| Dec 200929000 mi | Leather on driver's seat cracked and split open | ||
| Dec 201038000 mi | Carrier bearing failed on the driveshaft (AWD). Entire driveshaft was replaced as a result. | ||
| Jul 201385000 miUS $2100 | PCM failed and damaged the ignition coils and plugs requiring replacemet of all items. | ||
| Sep 2014105000 miUS $150 | Wheel bearings went bad on the front end. Both were replaced. | ||
2008 Ford Fusion 4dr Sedan
160-horsepower 2.3L I4 5-speed manual FWD
| Ford Fusion in Utah, United States Jan 2021 - Jun 2022 | |||
| Aug 2021189000 miUS $400 | Brakes | ||
| Jun 2022205000 miUS $400 | New serpentine belt | ||
| Ford Fusion in Florida, United States Jun 2015 - Jun 2015 | |||
| Jun 201581000 miUS $10 | Temp gauge would not come up to center. Code for coolant temp out of range found (P0128?) Replaced thermostat which fixed problem. Access was difficult and not for the first-timer. Daughter reported soft brake pedal. After application of ABS (hard braking) pedal would be very soft and brake performance was poor. Did complete brake fluid flush by manual bleeding which solved problem. Amazing improvement. | ||
| Ford Fusion in Utah, United States Apr 2008 - Jan 2012 | |||
| Oct 200930000 mi | Some type of oil cap was cracked, allowing oil to leak from engine compartment. | ||
| Ford Fusion in Ontario, Canada Jun 2012 - Oct 2017 | |||
| May 201352320 miC $250 | Blown steering line - hose had rubbed through. | ||
| Mar 201569440 miC $375 | Failure of PATS security system, required new keys and reprogramming. | ||
| Ford Fusion in Connecticut, United States - Feb 2008 | |||
| Feb 20081200 mi | Blower motor would squeak at low speeds. Found the fan bearing to be out of balance. Had to get the heater core blower fan and motor replaced. | ||
| Ford Fusion in Minnesota, United States Jan 2009 - Dec 2010 | |||
| Feb 20098000 mi | One repair - to replace SYNC system master unit. Took 3 days in Feb. Unsuccessful, is likely an unresolved software issue, not hardware. | ||
| Ford Fusion in Minnesota, United States Jul 2009 - Jul 2019 | |||
| Dec 201474000 miUS $120 | Valve cover gasket was leaking oil. My mechanic said it wasn't major but definitely leaking. He replaced it. | ||
| Mar 201692000 miUS $770 | Oil leak at timing chain cover. oil dripping on accessory belt causing it to squeal. | ||
| Dec 2017100000 miUS $500 | Power steering pump was leaking. Pump was replaced | ||
| Ford Fusion in Ohio, United States Sep 2007 - Jun 2011 | |||
| Oct 20071000 mi | Fuel pump pressure bleed down overnight | ||
| Ford Fusion in California, United States Sep 2010 - Aug 2011 | |||
| Dec 201071000 miUS $3000 | Lemon car all the way around. Had been noticing problems with the transmission when first bought car and under warranty. 2,000mi out of warr and transmission blew. Ford would not honor their part. We paid...they don't care. Will never buy Ford again. | ||
| Ford Fusion in Alberta, Canada Sep 2010 - Jun 2012 | |||
| Dec 201056420 mi | In the winter, the heat does not flow to the rear of the car. In fact, it actually blows cold air to the passengers in the back seat and also to the floor vent of the front passenger seat. Dealer never able to find problem. | ||
| Dec 201177500 mi | Driver's inside door handle would not work/door wld not open. Entire handle had to be replaced, take door apart to do this. (Also, Chrome on inside door handle peeling off, leaving sharp edge.) Rear Defrost stopped working after handle replaced. Dealer said coincidence. Not yet fixed. | ||
| Mar 201285560 miC $97 | Changed headlights. (It is a pain to do it on this car, so decided to take it to the dealer). Would like to see Ford make it a bit easier for the owner to access these small things. | ||
2008 Ford Fusion 4dr Sedan
160-horsepower 2.3L I4 5-speed automatic FWD
| Ford Fusion in Wisconsin, United States May 2013 - Aug 2023 | |||
| May 2017116000 miUS $50 | Thermostat replaced. It was causing a check engine light. | ||
| Feb 2022167000 miUS $350 | CV axle boot leaking. CV axle and hub bearing were rusted together. Replaced CV axle and Steering Knuckle. Also, replaced worn Tie Rod End. | ||
| Ford Fusion in Indiana, United States Feb 2010 - Jul 2013 | |||
| Oct 201030100 mi | Battery died 2.5 years after purchase. Dealer towed car, gave me rental for weekend, and replaced battery. No charge, just inconvenienced since occurred about 20 miles from home & dealer. | ||
| Apr 201136500 miUS $180 | driver door inside handle - mechanism broke (spring-like break inside door). Dealer would not cover repair, just outside 36,000 mile warranty. | ||
| Ford Fusion in Florida, United States May 2016 - Jun 2018 | |||
| Nov 201792000 miUS $800 | engine coolant replaced, radiator hoses replaced, thermostat replaced. thermostat had failed. | ||
| Jun 201897000 miUS $15 | Radio antenna had rusted through and broken off. Replaced antenna. | ||
| Ford Fusion in New Jersey, United States Jun 2017 - May 2022 | |||
| Oct 202087600 miUS $240 | Replaced Transmission FLuid lines | ||
| Nov 202088525 miUS $300 | Replaced Thermostat and Timing belts | ||
| Jan 2022110300 miUS $962 | the car cranked but didn't start - did not hear fuel pump prime system. Replaced Fuel Pump - repair delayed since pump had to be ordered from a dealer. | ||
| Ford Fusion in New York, United States Jul 2016 - Apr 2017 | |||
| Sep 201687000 miUS $900 | Rear brake replacement | ||
| Ford Fusion in Minnesota, United States Sep 2015 - Oct 2016 | |||
| Jul 2016136000 mi | Oil pan gasket. | ||
| Ford Fusion in Ohio, United States Dec 2017 - Oct 2021 | |||
| Jan 2018108000 miUS $500 | Bad transmission sensor and cable | ||
| Ford Fusion in Pennsylvania, United States Oct 2010 - Dec 2017 | |||
| May 201127400 mi | Drivers side front seat, left side upright cushion side bolster disintegrated at seam, was replaced. | ||
| Nov 201441300 miUS $900 | Noise corresponding to road speed. Some sort of shaft bearing was bad. Also replace alternator, thought that was problem. | ||
| Jul 201652200 miUS $175 | Front and rear sway bar end links worn out causing a rattle going over uneven surfaces. Rattle from both rear calipers. Both rear calipers were loose. Replaced mounting hardware and remounted calipers. | ||
| Mar 201758000 miUS $800 | Replaced front rotors for 2nd time, front brake pads and 4 new tires. | ||
| Jun 201760000 miUS $150 | Had to replace rear caliper hardware again. Had to reposition the the left front strut spring sadddle rubber on bottom, slid out of position. | ||
| Ford Fusion in Ohio, United States Jul 2008 - Jul 2018 | |||
| Mar 201454000 miUS $604 | All new brake pads & rotors, balky (sticking) LR caliper freed up. Even 3,000 miles later, car stops like brand new. Gas mileage went up 2 mpg city with LR caliper fixed. Corroded spot fixed on a wheel lip causing a tire leak at the bead. | ||
| Jan 201568800 miUS $1989 | In mid-Nov.'14 my brake pedal nearly went to the floor as the ABS kicked in. It didn't recover until the next day, then it was fine for 6 weeks. On 1-3-15 it happened again & stayed that way. Dealer replaced master cylinder & HCU. | ||
| Dec 201570000 miUS $461 | Left-rear brake caliper had seized, causing those pads to drag & make the whole assembly hot. A garage had freed it up in Spring 2014 but it obviously only lasted a year-and-a-half. A local Ford dealer replaced the caliper this time. Noticed an oil burning smell inside the car when not in motion, the engine warmed up & running. No visible smoke. Dealer replaced valve cover gasket & cleaned the engine. | ||
| Feb 201780000 miUS $697 | Engine light came on, I checked it & it read PO128 : a bad cooling thermostat. Car had been running cool so it was obviously stuck open. Garage changed it for $199.56 Front end squeak while turning at low speeds. Garage said tie-rod ends were bad & could be the problem, but said it''s usually ball joints even though mine were in good shape. Tie-rod ends replaced at $148.04 *note* ...The front end squeak never went away and I suspected my ball joints were very dry inside. In March I bought and used a grease needle. A ten-minute job and the car's front end is very quiet now :) | ||
| Jul 201782083 miUS $694 | Replaced all brake rotors and pads plus two calipers Recharged A/C system | ||
| Mar 201888000 miUS $120 | Power door lock actuator for the front passenger door failed. Bought a new one for $120 and replaced it myself. | ||
| Jul 201888500 miUS $264 | Had a fluid drip - not engine coolant - under the radiator. A local repair shop found the transmission lines going to the cooler built into the radiator were leaking and replaced them. | ||
| Ford Fusion in Minnesota, United States Sep 2008 - Mar 2016 | |||
| Jun 201593000 miUS $145 | Replace leaky valve cover gasket. | ||
| Jan 201691300 miUS $120 | intake manifold gasket | ||
| Ford Fusion in Pennsylvania, United States Nov 2008 - Dec 2012 | |||
| Feb 20098000 mi | Had PCM flashed to resolve the transmission's jerky shifting. Driver's side seat had cracks and was replaced. | ||
| Jul 200911000 mi | The center pieces of the Sport Appearance Package wheels were oxidizing. They were replaced. | ||
| Feb 201125500 mi | I noticed the check engine light so I took my car to a dealership. They found out it was a bad catalytic converter and it was replaced under the factory warranty. | ||
| Jun 201128000 mi | Replaced a slightly corroded hubcap. | ||
| Ford Fusion in Manitoba, Canada Jun 2008 - Oct 2015 | |||
| Feb 20098060 mi | After a cold soak ( -25 C) the heater / Air Conditioner computer stays blank and looses it's memory. The heater will not work until a manual selection is made. Ford is working on the problem. A fix not available yet. | ||
| Apr 200910540 mi | When cold soaked, the Air Conditioner / heater computer loses its memory and the heat will not come on when command start is used. Ford is working on a fix. | ||
| Sep 200915178 mi | auto dimming mirror intermittant. replaced auto dimming mirror replaced under warranty | ||
| Mar 201578740 miC $468 | thermostat stuck | ||
| Ford Fusion in New Jersey, United States Mar 2008 - Nov 2017 | |||
| Jan 2014119000 miUS $400 | Head gasket replaced | ||
| Oct 2015161700 miUS $300 | Valve kit replacement | ||
| Ford Fusion in New York, United States Dec 2007 - Nov 2014 | |||
| May 201110000 mi | They adjusted or replaced some sensors | ||
| Mar 201311000 miUS $200 | TPMS malfunction | ||
| Ford Fusion in Massachusetts, United States Apr 2008 - Mar 2012 | |||
| May 200912000 mi | Sun Roof retraction bar snapped, causing roof to twist and remain in up-right position. Entire unit needed replacement. | ||
| Jul 201136300 mi | Sunroof failure | ||
| Ford Fusion in British Columbia, Canada Mar 2008 - Oct 2015 | |||
| Oct 20084960 mi | Driver's seat makes internal rubbing sound when seatback pressed against on right side. Shop determined in-seat airbag assembly rubbing, could not resolve with standard procedures. Waiting for reply from manufacturer. | ||
| Dec 20085580 mi | Cracked internal seat frame replaced. Problem reduced but not eliminated. Continue work on seat. Shop damaged B-pillar cover when removing seat. New appointment in January to replace pillar cover. | ||
| Jan 20096820 mi | Dealer tried to fix seat once again and failed to do so. Ordered new foam seat core - the last original part of the seatback. Did not replace B-pillar cover as seat is expected to be removed again. Replacement of foam core of seatback finally solved the original problem. | ||
| Feb 201127280 mi | Replaced noisy (ticking) HVAC blower fan. Driver's side external window trim peeling away at top of window. | ||
| Ford Fusion in Michigan, United States Oct 2008 - Jun 2011 | |||
| Feb 201130000 mi | Leak from oil pan or transmission. | ||
| Ford Fusion in British Columbia, Canada Aug 2009 - Jun 2018 | |||
| Jun 201258900 mi | replace crankcase seal & coolant pump. | ||
| Feb 201363840 miC $50 | replace headlight. | ||
| Jun 201471300 miC $400 | replace thermostat | ||
| Jun 201792380 miC $170 | replace tire pressure sensor | ||
| Jul 201792380 miC $420 | Power window switch repair. | ||
| Oct 201794240 miC $400 | Back brakes | ||
| Ford Fusion in California, United States Apr 2011 - Dec 2016 | |||
| Nov 201345600 miUS $100 | Driver interior door handle broke, apparently a some what common problem. Bought a replacement off amazon and fixed myself | ||
| Ford Fusion in Pennsylvania, United States Aug 2012 - Dec 2017 | |||
| Oct 2016135500 miUS $800 | Braking ability diminished, ABS hydraulic and control module replaced. | ||
| Ford Fusion in Wisconsin, United States Jun 2012 - Sep 2016 | |||
| Aug 201374400 miUS $45 | The driver door handle cracked at approximately 74,000 miles and was replaced shortly after. Very simple D.I.Y. job in my opinion. | ||
| Mar 201482000 miUS $215 | Replaced valve cover seals to stop minor oil leak. Replace both tie-rod ends | ||
| Mar 2016107000 miUS $330 | Parking brake sticking on rear passenger wheel. Cleaned hardware and replaced rotors and pads. Problem solved. | ||
| Ford Fusion in Minnesota, United States Dec 2010 - Dec 2021 | |||
| Feb 201132000 miUS $500 | Coil pack and all spark plugs. Coil pack and all spark plugs | ||
| Ford Fusion in Indiana, United States Oct 2010 - Jan 2014 | |||
| Nov 201031000 mi | Both front door windows had vertical scratches. An Internet search led me to a TSB that addressed this problem. Ford dealer ordered parts. CEL had code read at AutoZone P2004 IMRC stuck open. Left car with dealer for a day.They acknowledged the problem but were unable to service the car that day.2 days later the CEL reset.Will wait to see if it happens again. | ||
| Ford Fusion in North Carolina, United States Jun 2009 - Jul 2015 | |||
| Oct 201368800 miUS $320 | Torn CV Boot | ||
| Ford Fusion in Massachusetts, United States Sep 2009 - Jul 2017 | |||
| Oct 201037000 miUS $200 | Car failed to start. jump started by AAA. Car driven to dealer who replaced the battery and tested systems. Told battery was 'Worn out" out of warranty replacement. Approx $150 out of pocket cost Clicking noise from heater fan. Parts replaced under extended warranty. $50 decuctable and rental car reimbustment. | ||
| Nov 201151000 miUS $200 | Sunroof wouldn't 'seat' properly when closed. Determined that the frame was cracked. Replaced no charge under extended warranty Chirping sound from heater fan previously replaced 1 yr ago re-occured and the shop replaced the part again. | ||
| Aug 201263700 miUS $190 | INTERIOR DRIVERS SIDE DOOR HANDLE MALFUNCTION | ||
| Feb 201491000 miUS $370 | Check engine reveled an air intake item needed reoplacement | ||
| Ford Fusion in Minnesota, United States Sep 2013 - Jun 2018 | |||
| Dec 201328000 miUS $262 | Replaced thermostat | ||
| Apr 201535000 miUS $100 | Bearing howling. small water leak CD's stuck in multi disc changr Blower motor noisy when cold | ||
| Jul 201748033 miUS $100 | Timing Belt Tensioner | ||
See TrueDelta's information for all Sedans
See TrueDelta's information for all Ford models.
