| 1 | 0 | 3 | 4 | 3 | 4 |
2007 Ford Expedition repairs by problem area
Engine (28%)
Transmission and Drivetrain (15%)
Brakes and Traction Control (6%)
Suspension and Steering (10%)
Electrical and Air Conditioning (28%)
Paint, Rust, Leaks, Rattles, and Trim (7%)
Other (5%)
Chart based on 155 repairs.
2007 Ford Expedition repair cost distribution
$2500+ (3%)
$1000 - $2499 (9%)
$500 - $999 (20%)
$100 - $499 (39%)
< $100 (28%)
Chart based on 120 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2007 Ford Expedition
Engine not specified
| Ford Expedition in Kentucky, United States Jun 2013 - Dec 2013 | |||
| Sep 201382000 miUS $120 | The air conditioner and heater buttons wouldn't work most of the time. The air kicked on when it wanted to. Took it to Ford They would not sure of the problem, we would have to pay for part first. charged $120 to do nothing a lot of wethink The navigation went out took it to Ford, again they were guessing not sure but we could buy the part for over $400 and they would try it. Charged to look at it $120. Said I may need a new cd I ask if they tried one there, they don't have one | ||
| Ford Expedition in Alabama, United States May 2013 - Jul 2013 | |||
| Jul 2013103000 miUS $350 | power steering radiator leak | ||
2007 Ford Expedition 4dr SUV, ext.
300-horsepower 5.4L V8 6-speed automatic RWD
| Ford Expedition in South Carolina, United States Aug 2013 - Jul 2015 | |||
| Oct 201475300 miUS $375 | Drivers side seat would not go forward / backward. Stuck in farthest most back position. | ||
| Ford Expedition in Virginia, United States Mar 2010 - Apr 2012 | |||
| Jul 201151000 miUS $350 | no ac. new clutch on a/c compressor | ||
| Mar 201263000 miUS $2000 | Ac compressor locked up. Complete ac system became contaminated. | ||
| Ford Expedition in Florida, United States Dec 2016 - Dec 2017 | |||
| Jul 2017156667 miUS $2100 | transmission slips badly | ||
| Ford Expedition in Florida, United States Nov 2010 - Apr 2013 | |||
| Apr 201387000 mi | Heat does not blow on the drivers side. Only cold air through the vents to the floor | ||
| Ford Expedition in Virginia, United States May 2015 - Jun 2019 | |||
| Mar 2017111000 miUS $300 | Trans flush and filter replacement | ||
| Jun 2018122000 miUS $500 | R and r lower ball joints | ||
| Ford Expedition in Alberta, Canada Mar 2010 - Sep 2012 | |||
| Jul 201148980 mi | Front and rear differential pinion seals leaking. Both pinion seals replaced under warranty. | ||
| May 201257440 mi | Leaking front axle output seal | ||
2007 Ford Expedition 4dr SUV, ext.
300-horsepower 5.4L V8 6-speed automatic 4WD w/low range
| Ford Expedition in Virginia, United States Oct 2013 - Sep 2016 | |||
| Nov 201499000 miUS $920 | Replaced failed fuel pump. Had to tow truck to shop. | ||
| Mar 2015108000 miUS $500 | Spark Plugs | ||
| Ford Expedition in Colorado, United States Nov 2012 - Dec 2013 | |||
| Dec 201353000 miUS $600 | brakes were going squishy, they would almost go to the floor. Replaced pads,bled the brakes about 4 times, replaced master cylinder--that didn't help. They still weren't working when we pulled the car. | ||
| Ford Expedition in California, United States Feb 2013 - Jun 2018 | |||
| Feb 201585700 miUS $400 | Wheel bearing replaced. | ||
| Jun 2016100000 miUS $350 | Fuel line disconnected from the fuel filter. Upon examination it was attached with a zip tie rather than the OEM clamp Plastic part on coolant line failed resulting in coolant spill in engine bay | ||
| Jul 2017113000 miUS $450 | Had rust in two cylinders but was diagnosed on two separate occasions. | ||
| Jan 2018120000 miUS $4566 | Replacement of spark plugs and ignition coil Rear axle had multiple points of fluid leak. Repaired, sealed and replaced fluids Replace brake pads and machine rotors | ||
| Feb 2018124000 miUS $650 | Coolant leak due to clamp failure. Clamp failure was due to improper clamp installed at a different repair shop approximately 3 year ago. | ||
| Apr 2018128000 miUS $400 | AC system had air in it (as opposed to coolant). Released air and topped off coolant. Tightened attachments and other fittings of rear axle. | ||
| Ford Expedition in New Hampshire, United States May 2011 - Mar 2014 | |||
| Apr 201286700 miUS $897 | ABS light was went on and off for 2 months. ABS actually activated while driving normally in traffic. Scary! New parts: new rear speed sensor, hub (can't buy just the bearings!!), rear axle seal. (Also included new serp belt.) | ||
| Nov 2012106600 miUS $950 | The steering shaft u-joint was binding (felt like PS pump failure, grab then loose, then grab again). Also had rear hub changed. Bearings were getting rusty, but still worked. | ||
| Ford Expedition in New York, United States Mar 2010 - Sep 2015 | |||
| Apr 201150000 miUS $350 | Was routine service and removal of a nail in the tire. Nail removed but it seems the air sensor was not put back in properly. | ||
| Sep 201154000 miUS $34 | Traction control is occasionally kicking in for no reason. Also rear hatch isn't opening or closing automatically anymore. First part was ordered, second they didn't get to. | ||
| Jan 201361000 miUS $550 | Driver window regulator needed replacement and rear hatch wouldn't open automatically. The rear hatch problem has been ongoing for years. | ||
| Mar 201587000 miUS $2500 | Brakes was normal wear. Vacuum drum issue on front wheels causing vibration and issue. Rear seat belt not retracting. Power windows not moving quickly. One motor about to go. | ||
| Apr 201587500 miUS $1800 | vacuum things in front wheels. There was a leak due to seal issues. Part needed to be replaced on both sides | ||
| Ford Expedition in Pennsylvania, United States May 2010 - Jun 2018 | |||
| Jul 2013133700 miUS $2800 | Sunroof track required replacement due to the glass panel jamming. New track needed. Radiator leaking at transmission coolant lines and other places. Radiator replaced. Rear axle seals leaking. | ||
| Nov 2013139600 miUS $1500 | Replace all 4 ball joints | ||
| Mar 2014146000 miUS $350 | Leakage from bulkhead connector. | ||
| Dec 2014152000 miUS $1600 | New fuel pump needed Alignment needed, upper control arm bushing replaced. Previous shop did not align after replacing upper control arm. | ||
| Apr 2017184000 miUS $120 | Calipers sticking. Pulling to one side when braking. Replaced calipers, rotors pads and left brake line. Pulled to right when braking. Replaced right front brake line | ||
| Feb 2018194000 mi | Replaced valve body | ||
| Ford Expedition in Ontario, Canada Oct 2010 - Sep 2015 | |||
| Nov 201055180 miC $300 | Driver side electric window failure - disconnected from track. New part ordered and replaced under warranty with $ 100 deductible. | ||
| Oct 201173780 miC $100 | Gutter drain in sunroof clogged causing backup of water over gutter into passenger compartment | ||
| Mar 201284940 mi | Seal failure in rear differential, losing fluid regularly for 12 months but finally diagnosed. Bearing replacement in driver front wheel. Auto door unlock feature not unlocking rear doors | ||
| Jul 2013108460 miC $300 | Tailgate window hinges sheared off - no warranty or recall information - though appears online to be a common problem. | ||
| Jul 2015142600 miC $1000 | Replaced throttle body assembly due to rough idling (chugging) Throttle body assembly did not solve poor idle. Variable Cam Timing (VCT) solenoids replaced | ||
| Sep 2015142600 mi | Engine seizure Needs bodywork and front end work as well so it would be a losing cause to keep it going. | ||
| Ford Expedition in Illinois, United States Jan 2014 - Jun 2018 | |||
| Feb 201476500 mi | Paint peeling from trunk and hood. Large patches. Dealer won't fix it because the warranty is for corrosion AND perforation meaning the rust must be deep enough to cause holes. Hearted and cooled seat fan makes rattling noise and stops. | ||
| Mar 201478000 mi | Due to two piece spark plug design, the bottom but of the spark plug gets stuck and breaks off. Used special tool to remove three broken spark plugs. IWE solenoid was bad. Replaced Front "FORD" emblem faded | ||
| Apr 201478200 mi | Power trunk actuator not working. Adjusted gears and lubber rod | ||
| Jul 201479700 mi | External temperature thermostat returning incorrect temperature reading Power mirror fold and adjuste inoperative Passenger airbag cover middle seam torn | ||
| Jul 201588300 miUS $75 | Freon low. Recharged with home kit | ||
| Sep 201590000 miUS $300 | Fuel delivery system | ||
| Feb 201693100 miUS $200 | Brake line failure | ||
| Jun 201696000 miUS $40 | Wheel lug frozen. Chrome lug nut (OEM FORD). It was rusted from inside and the whole lug nut had bulged up to a point where the tire iron socket would not fit. Brake shims and sliding pin replaced. The caliper was not riding on the pin properly due to heavy brake dust accumulation. | ||
| Aug 201697100 miUS $300 | VCT solenoid and valve cover gasket replaced | ||
| Nov 2017105800 mi | Steering wheel control for volume was shorted out resulting in sudden and erratic volume changes (all the way to max without user input) Took it all apart and noticed some lite corrosion which I cleaned and it’s working again | ||
| Dec 2017105800 miUS $150 | Evap purge valve failed. Replaced gas cap evap purge valve as well as evap vent valve as recommended by specialists. | ||
| Jan 2018106200 miUS $22 | Starter motor replaced. Even with new battery, cranking in cold weather was slow. Passenger side exhaust manifold replaced. Improper design led to warping of the manifold and snapping the manifold bolts. Manifold, gasket and updated stainless bolts. Upper, lower, left and right o2 sensors. Rear glass support shocks collapsed leading to rear glass closely vigorously and fast creating a dangerous condition. | ||
| May 2018108000 mi | Randomly changes from dvd, am, fm, Sirius, nav with buttons inoperative | ||
| Ford Expedition in Arizona, United States Nov 2013 - Jul 2016 | |||
| Nov 2013112000 miUS $500 | When downshifting transmission would make car jolt, transmission had to be recomputed The ac door in the front had gone out so it had to be replaced | ||
| Jul 2016137000 miUS $1000 | Camshaft bearing went bad and so did a rocker arm, had to replace both camshaft bearing | ||
2007 Ford Expedition 4dr SUV
300-horsepower 5.4L V8 6-speed automatic RWD
| Ford Expedition in Texas, United States Mar 2008 - Dec 2014 | |||
| Jul 200834000 mi | continuing squeak in left side of dash - no fix after 4 times in for repairs continuing warm weather squeal from rear hydraulic lifts - replaced once; no help low cooling in A/C seats - upgraded the fan | ||
| Jul 200957000 mi | front dash goes dead - no a/c, no radio, nothing. Turn it off and back on and it's fine. My other Ford trucks did this also. Dealer says they cannot replicate and pretend they've never heard of it before. They lie. | ||
| Ford Expedition in Ohio, United States Feb 2014 - Sep 2020 | |||
| Aug 2014129600 miUS $400 | Reset shift points to remedy lag when accelerating from a stop. Also changed transmission fluid. | ||
| Jul 2016141800 miUS $350 | Replaced Front evap valve (leaks). | ||
| Feb 2018156500 miUS $200 | Squirrel gnawing damage to ignition wiring; some wires were replaced. [rodent] | ||
| Apr 2018158000 miUS $140 | Replaced driver window regulator system | ||
| Jun 2018159000 miUS $75 | Replaced front passenger window regulator | ||
| Jan 2020171913 miUS $345 | Replace seal in rear differential Replace exhaust manifold, passenger side. | ||
| Apr 2020173386 miUS $450 | replaced rear axle seals | ||
| Jul 2020174415 miUS $700 | Replaced starter system | ||
| Sep 2020176000 miUS $380 | Rear bearing replaced | ||
| Ford Expedition in Virginia, United States Oct 2014 - Apr 2016 | |||
| Sep 201579000 mi | interior driver side door handle broke | ||
| Nov 201581500 mi | Cylinder #4 misfire CEL past 1 month from failed coil packs and/or spark plugs gone bad. Misfire CEL identified by scanning diagnostic tool. I've decided to just replace all 8 coil packs & spark plugs at the same time. | ||
| Ford Expedition in North Carolina, United States Apr 2012 - Jun 2018 | |||
| Dec 201283000 miUS $1200 | no start replaced fuel pump and spark plugs | ||
| May 2016139900 miUS $600 | Replaced 1 ignition coil | ||
| Sep 2016147000 miUS $200 | Replaced defective battery | ||
| Nov 2016150100 miUS $3400 | Torque converter lockup slipping and stuttering. Transmission replaced. | ||
| Jun 2017163000 miUS $1300 | Replace both front window regulators Replace smart junction box to fix inoperable hazard lights | ||
| Ford Expedition in Florida, United States Feb 2012 - Oct 2012 | |||
| Mar 2012124000 miUS $380 | sputter when maintaining speed. smell fuel. front AC does not come on at times. after driving 10 mins. sometimes it starts working. Air is cold and blowing hard. | ||
| Oct 2012128000 mi | front AC did not come on sometimes. | ||
| Ford Expedition in Georgia, United States Apr 2010 - Jul 2016 | |||
| Jul 201298000 miUS $670 | replace coil on one cylinder not firing | ||
| Mar 2014135000 miUS $926 | Right rear strut was losing fluid. Due to mileage on original struts; had all four replaced. | ||
| Dec 2014158000 miUS $980 | Coil on Cylinder #5 failed. Check on all other coils revealed three other potential problematic. Chose to replace all eight coils duel to mileage. Also had front brake pads replaced. | ||
2007 Ford Expedition 4dr SUV
300-horsepower 5.4L V8 6-speed automatic 4WD w/low range
| Ford Expedition in Michigan, United States Mar 2010 - Apr 2022 | |||
| Feb 201162000 miUS $611 | replace transfer case rear output seal | ||
| Mar 201275000 miUS $154 | replaced battery | ||
| Feb 201384700 miUS $414 | DRIVER DOOR WINDOW CRANK MECHANISM REPAIR | ||
| Jun 201389000 miUS $425 | repaired rust on back tailgate and re-painted | ||
| Aug 201392300 miUS $1700 | oil leaks. replaced 1) valve cover gasket 2) oil pan gasket 3) oil filter gasket | ||
| Apr 2014105800 mi | replace R Rear Axle Seal;left front axle seal and Rear transfer case seal | ||
| Sep 2014118000 miUS $300 | replaced window regulator | ||
| Jun 2015135000 miUS $100 | Attempted to diagnose rattle in the dashboard. Dealer could not determine the problem. Owner chose NOT to spend an additional 4 hours of diagnostic time to determine the issue (I will live with it). | ||
| Dec 2015146000 miUS $288 | replaced belt tensioner | ||
| Jun 2016154000 miUS $290 | replace oil dipstick tube - rusted replace right rear shock - leaking | ||
| Aug 2017173592 miUS $170 | replace tire sensor | ||
| Mar 2018180188 miUS $1068 | replace right rear hub/wheel bearing and sensor replace left rear strut and worn left rear upper control arm (rear ward) | ||
| Sep 2018183000 miUS $235 | replace hvac blower | ||
| Oct 2019196000 miUS $500 | replace coil wires | ||
| Sep 2020200000 miUS $1120 | replace electric window motor - not working replace fog lamp and assembly | ||
| Ford Expedition in Illinois, United States Mar 2008 - Sep 2013 | |||
| Jul 200833000 mi | Transmission reflashed to fix 2-1 gear downshifting issue. | ||
| Dec 200959500 miUS $200 | Developed a miss and check engine light. Turned out to be bad coil pack on # 5 cylinder. | ||
| Sep 201074000 mi | Faulty HVAC fan control module. HVAC fan was stuck on high. Module replaced HVAC system fully operable. | ||
| Feb 201179000 miUS $450 | Driver's door window stopped working. Had to have motor and actuator replaced. | ||
| Aug 201190000 mi | Drivers window would not properly go down, the motor would run a second then the window would drop about 3". Dealer adjusted the actuator which fixed the problem. | ||
| Mar 201299000 miUS $120 | Had to replace drive shaft seal in rear differential | ||
| Ford Expedition in Ohio, United States Mar 2010 - Jun 2022 | |||
| Jun 201690000 miUS $1100 | Replace failed fuel pump | ||
| Ford Expedition in Virginia, United States Nov 2016 - Jun 2018 | |||
| Nov 2016123000 mi | rusted out rocker panels under driver and passenger front doors | ||
| Mar 2017129000 miUS $50 | air flow module changed for rear | ||
| Ford Expedition in Kazakhstan Mar 2011 - Jul 2018 | |||
| Apr 201123960 mi$900 | Need to replace the Airbag central controller. Update: In Kazakhstan--it has now been over a year since the part was ordered. | ||
| Apr 201232740 mi$700 | The heating hose was leaking | ||
| Jul 201859520 mi$385 | Replacement of leaked condenser | ||
| Ford Expedition in Arizona, United States Dec 2013 - Jun 2018 | |||
| Sep 2015110000 mi | Engine cranked for an extended time before starting. Shop performed diagnostic testing with their equipment that suggested low voltage during cranking may be the cause. Shop replaced the battery and all is working OK now. | ||
| May 2016115000 miUS $200 | Check engine light came on. 1st trip to repair-no trouble found. Check engine light on again. miss detected upon light acceleration. Code showed misfire. replaced #2 coil pack. checks ok now. | ||
| Jun 2016116000 miUS $875 | Power steering pump growling. Took it to the shop to be diagnosed. Found power steering cooler leaking. Power steering cooler is part of the A/C condenser assembly which required the A/C system to be serviced when the assembly was replaced | ||
| Mar 2017120000 miUS $450 | Unable to shift from park. Found brake light switch not working and replaced. Significant oil leak. Found defective oil cooler, replaced. | ||
| May 2018128000 miUS $500 | engine misfired intermittently upon light acceleration around 40 mph. Shop diagnosed multiple coil packs defective. Replaced all coil packs. | ||
| Ford Expedition in Georgia, United States Apr 2010 - Sep 2013 | |||
| Mar 201026000 mi | Third row seat automatic up/down broke plastic part and leather ripped. But fixed under warranty. | ||
| Jun 201026000 mi | Vibration and jumpiness felt at any speed. Dealer says it is normal for this type of vehicle. Expedition 4x4 then don't have a good ride. | ||
| Ford Expedition in Maryland, United States Sep 2012 - Feb 2017 | |||
| Jan 2015US $173 | "Wrench" warning light came on, went into "limp home" mode. Threw code "po61b", mechanic reset code but doesn't know the cause. Transmission flush and fluid change. Nothing else actually done. Has not recurred, running OK now. | ||
| Sep 2015130000 miUS $340 | Whining sound from engine compartment rising and falling in pitch in step with RPM's. Shop replaced serpentine belt, pulley, idler, Tensioner (?). | ||
| Jun 2016139000 miUS $475 | Transmission shifting improperly. Shifter harness mis-aligned, readjust - This vehicle is SSV, shifter is column mounted, retail vehicle has floor shift. | ||
| Jan 2017146000 mi | Intermittent problem: Sometimes 6 speed transmission feels like it won't shift above 4th or 5th gear. Been to 5 different shops, some more than once. Won't do it when mechanic drives it. no one can diagnose or fix it. No codes or dash lights. Decided to get rid of it. | ||
| Ford Expedition in Connecticut, United States Mar 2010 - Oct 2021 | |||
| Aug 201039300 miUS $25 | Rear turn signal bulb replaced. | ||
| Dec 201368000 miUS $90 | Suspected transmission leak. Left with dealer. No leak. Dealer put in dye to test for leak. No trace of dye. Truck leaked 3 weeks later. No trace of dye found. Truck left for 3 days at dealer (usually happens when truck sits). No trace. | ||
| Dec 201584000 miUS $1800 | Transmission was leaking. Found transmission bulkhead connector leaking. Replaced, changed filter, replaced fluid. Serpentine belt cracked and replaced. Corroded wire noted when spark plugs were replaced causing misfire on cylinder number 4. Wire replaced. | ||
| Nov 2019128000 miUS $950 | Fuel pump replacement. Mechanic saved the part to show it had overheated and started to melt. | ||
| Dec 2019128000 miUS $100 | Replaced window regulator. Third time on this truck and second for this window. Wasn't going to pay dealer $650 to do it again so I ordered the part, watched a YouTube video, and repaired it myself. | ||
See TrueDelta's information for all SUVs
See TrueDelta's information for all Ford models.
